Optimizing Laundry Wastewater Treatment: A Hybrid Approach Using Poly-Aluminum Chloride Coagulation and Activated Carbon Adsorption

Sugito Sugito; Aliffia Rica Ambima; Muhammad Al Kholif; Firda Lutfiatul Fitria

doi:10.12962/j25481479.v10i1.22559

Optimizing Laundry Wastewater Treatment: A Hybrid Approach Using Poly-Aluminum Chloride Coagulation and Activated Carbon Adsorption

Sugito Sugito, Aliffia Rica Ambima, Muhammad Al Kholif, Firda Lutfiatul Fitria

Abstract

Laundry wastewater contains high levels of Chemical Oxygen Demand (COD) and phosphate (PO₄), contributing to water pollution and eutrophication. This study investigates an integrated treatment approach using poly-aluminum chloride (PAC) coagulation and activated carbon adsorption to improve wastewater treatment efficiency. The research aims to determine the optimal PAC dosage (10% and 15%) and stirring time (0, 5, 15, 30, and 45 minutes) for maximizing COD and PO₄ removal. A batch reactor system was used to conduct the treatment process, and the analysis followed the Indonesian National Standard (SNI) methods. The results demonstrated that the highest removal efficiencies were achieved with a 15% PAC dosage and a stirring time of 45 minutes. Under these conditions, COD levels were reduced from 2189.62 mg/L to 143.47 mg/L, achieving a 93% reduction. Similarly, PO₄ levels decreased from 94.33 mg/L to 5.18 mg/L, corresponding to a 96% removal rate. These findings indicate that the combination of PAC coagulation and activated carbon adsorption is a highly effective treatment method for reducing pollution in laundry wastewater. This hybrid approach meets environmental discharge standards and presents a sustainable solution for large-scale wastewater treatment applications.

Keywords

Laundry wastewater treatment; Poly-Aluminum Chloride (PAC); Activated carbon adsorption; COD reduction; PO4 removal

Full Text:

PDF

References

A. Aqilah, “Laundry Effluent Environmental Impact Potential Analysis Using Life Cycle Assessment Approach,” in International Conference on Sustainable Engineering, Infrastructure and Development, ICO-SEID 2022, Jakarta, Nov. 2023. doi: 10.4108/eai.23-11-2022.2341591.

Pungut, M. Al Kholif, and W. Diah Indah Pratiwi, “Penurunan kadar chemical oxygen demand (COD) dan fosfat pada limbah laundry degan metode adsorpsi,” Jurnal Sains & Teknologi Lingkungan, vol. 13, no. 2, pp. 155–165, Jun. 2021, doi: 10.20885/jstl.vol13.iss2.art6.

J. Sutrisno, M. Al Kholif, L. Purwanti, and I. Nurhayati, “Bibliometrics analysis and future study trends in anaerobic biofilter systems for laundry wastewater treatment,” International Journal of Marine Engineering Innovation and Research, vol. 9, no. 3, pp. 2548–1479, Aug. 2024, doi: 10.12962/J25481479.V9I3.21544.

F. A. Hafidhin et al., “Penerapan teknologi fitoremediasi menggunakan tanaman eceng gondok untuk mengolah air limbah laundry,” Jurnal Ilmu Alam dan Lingkungan, vol. 14, no. 2, Aug. 2023, doi: 10.20956/jal.v14i2.28000.

S. Hu, B. Zhang, and Y. Xu, “Using Electric Flocculation to Treat Domestic Laundry Wastewater With Different Types of Detergents,” E3s Web of Conferences, vol. 261, p. 04008, 2021, doi: 10.1051/e3sconf/202126104008.

C.-T. Wang, W.-L. Chou, and Y.-M. Kuo, “Removal of COD from laundry wastewater by electrocoagulation/electroflotation,” J Hazard Mater, vol. 164, no. 1, pp. 81–86, 2009, doi: https://doi.org/10.1016/j.jhazmat.2008.07.122.

S. Vasiljevic et al., “Efficiency of Coagulation/Flocculation for the Removal of Complex Mixture of Textile Fibers From Water,” Processes, vol. 11, no. 3, p. 820, 2023, doi: 10.3390/pr11030820.

H. Budiastuti, “Carbonization of Rice Husk for Adsorption of Phosphate Compounds: Influence of Temperature and NaOH Activator,” E3s Web of Conferences, vol. 479, p. 04004, 2024, doi: 10.1051/e3sconf/202447904004.

H. S. Titah and F. N. Nasir, “The Use of Granular Activated Carbon and Zeolite as an Adsorbent to Reduce the Concentration of Phosphate, Chemical Oxygen Demand and Total Suspended Solid in Laundry Wastewater,” Journal of Ecological Engineering, vol. 25, no. 4, pp. 170–183, 2024, doi: 10.12911/22998993/184089.

E. Siswoyo, A. W. Utari, and L. G. N. Mungkari, “Adsorption Combined Phytoremediation System for Treatment of Laundry Wastewater,” Matec Web of Conferences, vol. 280, p. 05002, 2019, doi: 10.1051/matecconf/201928005002.

H. N. J. Hoong and N. I. Ismail, “Removal of Dye in Wastewater by Adsorption-Coagulation Combined System With Hibiscus Sabdariffa as the Coagulant,” Matec Web of Conferences, vol. 152, p. 01008, 2018, doi: 10.1051/matecconf/201815201008.

A. Al-Gheethi, R. Mohamed, A. A. Wurochekke, N. R. Nurulainee, J. M. Rahayu, and M. Hashim, “Efficiency Of Moringa Oleifera Seeds for Treatment of Laundry Wastewater,” Matec Web of Conferences, vol. 103, p. 06001, 2017, doi: 10.1051/matecconf/201710306001.

S. Anappara, G. Arthanareeswaran, Y. L. Thuyavan, A. F. Ismail, and S. Chakraborty, “Treatment of Laundry Wastewater Using Polyethersulfone/Polyvinylpyrollidone Ultrafiltration Membranes,” Ecotoxicol Environ Saf, vol. 121, pp. 174–179, 2015, doi: 10.1016/j.ecoenv.2015.04.004.

W. J. Ng, “Hibiscus Sabdariffa as Coagulant to Treat Laundry Wastewater,” J Phys Conf Ser, vol. 2923, no. 1, p. 012014, 2024, doi: 10.1088/1742-6596/2923/1/012014.

N. A. A. M. Rodzi, “Analysis of Algae and Bacteria Mixture in Removing Pollutants From Laundry Wastewater,” IOP Conf Ser Earth Environ Sci, vol. 1303, no. 1, p. 012021, 2024, doi: 10.1088/1755-1315/1303/1/012021.

O. L. and Z. Gbagba, “Sustainable Water Supply: Potential of Recycling Laundry Wastewater for Domestic Use,” Journal of Civil Engineering and Environmental Sciences, pp. 056–060, 2017, doi: 10.17352/2455-488x.000029.

D. Polak and M. Szwast, “Preliminary Studies on Integrated Process of Microfiltration and Photocatalysis Used in Laundry Wastewater Treatment,” Engineering and Protection of Environment, vol. 21, no. 2, pp. 163–170, 2018, doi: 10.17512/ios.2018.2.4.

A. B. E. García, K. Szymański, S. Mozia, and J. A. S. Pérez, “Treatment of Laundry Wastewater by Solar Photo-Fenton Process at Pilot Plant Scale,” Environmental Science and Pollution Research, vol. 28, no. 7, pp. 8576–8584, 2020, doi: 10.1007/s11356-020-11151-x.

N. Herlina, T. L. Muhammad, A. Husin, and P. Ihmawani, “Studies on Decreasing Chemical Oxygen Demand (COD) on Artificial Laundry Wastewater Using Anaerobic-Aerobic Biofilter Dipped With Bio Ball Media,” Matec Web of Conferences, vol. 276, p. 06015, 2019, doi: 10.1051/matecconf/201927606015.

E. Bazrafshan, F. K. Mostafapour, M. Farzadkia, K. A. Ownagh, and A. H. Mahvi, “Slaughterhouse Wastewater Treatment by Combined Chemical Coagulation and Electrocoagulation Process,” PLoS One, vol. 7, no. 6, p. e40108, 2012, doi: 10.1371/journal.pone.0040108.

S. Bering, J. Mazur, K. Tarnowski, M. Janus, S. Mozia, and A. W. Morawski, “The Use of Moving Bed Bio-Reactor to Laundry Wastewater Treatment,” in International Conference on Advances in Energy Systems and Environmental Engineering (ASEE17), 2017, p. 00015. doi: 10.1051/e3sconf/20172200015.

N. A. Yaranal, “Identification, Removal of Microplastics and Surfactants From Laundry Wastewater Using Electrocoagulation Method,” Water Emerging Contaminants & Nanoplastics, vol. 3, no. 1, 2023, doi: 10.20517/wecn.2023.46.

J. Naumczyk, J. Bogacki, P. Marcinowski, and P. Kowalik, “Cosmetic Wastewater Treatment by Coagulation and Advanced Oxidation Processes,” Environ Technol, vol. 35, no. 5, pp. 541–548, 2013, doi: 10.1080/09593330.2013.808245.

J. Liu and Q. Liu, “Coagulation-SBR Combined Processes for the Treatment of Papermaking Wastewater,” in 2010 International Conference on E-Product E-Service and E-Entertainment, 2010, pp. 1–4. doi: 10.1109/iceee.2010.5660715.

A. Gasmi et al., “Comparative Study of Chemical Coagulation and Electrocoagulation for the Treatment of Real Textile Wastewater: Optimization and Operating Cost Estimation,” ACS Omega, vol. 7, no. 26, pp. 22456–22476, Jul. 2022, doi: 10.1021/acsomega.2c01652.

M. R. Audria, T. Joko, and S. Sulistiyani, “The Effectiveness of Poly Alumunium Chloride (PAC) on Chemical Oxygen Demand (COD) Levels of Laundry Wastewater in Batam City, Indonesia,” International Journal of Environment, Agriculture and Biotechnology, vol. 7, no. 2, pp. 120–126, 2022, doi: 10.22161/ijeab.72.13.

W. Wang, L. Qi, P. Zhang, J. Luo, and J. Li, “Removal of COD in wastewater by magnetic coagulant prepared from modified fly ash,” Environmental Science and Pollution Research, vol. 29, no. 34, pp. 52175–52188, 2022, doi: 10.1007/s11356-022-19540-0.

T. Y. Nayir, O. Dinc, S. Kara, A. Akyol, and A. Dimoglo, “Laundry wastewater treatment by peroxi-coagulation,” Desalination Water Treat, vol. 182, pp. 98–108, 2020, doi: https://doi.org/10.5004/dwt.2020.25188.

C. de Oliveira Cardoso Nascimento, M. T. Veit, S. M. Palácio, and G. da Cunha Gonçalves, “Use of Natural Coagulants in the Removal of Color and Turbidity from Laundry Wastewater,” Water Air Soil Pollut, vol. 232, no. 7, p. 300, 2021, doi: 10.1007/s11270-021-05253-6.

W. Odhaib, A. J. Jaeel, and C. Wadees, “Color and COD Removal from Textile Effluent Using Alum and FeCl3 Coagulation,” Wasit Journal of Engineering Sciences, vol. 11, no. 1, pp. 126–133, Apr. 2023, doi: 10.31185/ejuow.vol11.iss1.429.

Q. Feng et al., “An improved kinetic model for dephosphorization of laundry wastewater by electrocoagulation,” Journal of Water Process Engineering, vol. 39, p. 101750, 2021, doi: https://doi.org/10.1016/j.jwpe.2020.101750.

S. Vishali, E. Poonguzhali, I. Banerjee, S. S. George, and P. Srinivasan, “Purification of domestic laundry wastewater in an integrated treatment system consists of coagulation and ultrafiltration membrane process,” Chemosphere, vol. 314, p. 137662, 2023, doi: https://doi.org/10.1016/j.chemosphere.2022.137662.

R. Perumalsamy, K. Chithra, S. Ajith, and S. V Prasad, “Optimization of Pharmaceutical Wastewater Treatment by Electrocoagulation and Dual Coagulation,” Water and Environment Journal, vol. 36, no. 3, pp. 525–540, 2022, doi: 10.1111/wej.12784.

N. Saifuddin and S. Dinara, “Pretreatment of Palm Oil Mill Effluent (POME) Using Magnetic Chitosan,” J Chem, vol. 8, no. S1, 2011, doi: 10.1155/2011/427532.

A. Hak, Y. Kurniasih, and H. Hatimah, “Efektivitas Penggunaan Biji Kelor (Moringa Oleífera, Lam) Sebagai Koagulan Untuk Menurunkan Kadar TDS Dan TSS Dalam Limbah Laundry,” Hydrogen Jurnal Kependidikan Kimia, vol. 6, no. 2, p. 100, 2019, doi: 10.33394/hjkk.v6i2.1604.

N. P. Sibiya, S. Rathilal, and E. K. Tetteh, “Coagulation Treatment of Wastewater: Kinetics and Natural Coagulant Evaluation,” Molecules, vol. 26, no. 3, p. 698, 2021, doi: 10.3390/molecules26030698.

M. R. Islam and M. G. Mostafa, “Characterization of textile dyeing effluent and its treatment using polyaluminum chloride,” Appl Water Sci, vol. 10, no. 5, p. 119, 2020, doi: 10.1007/s13201-020-01204-4.

S. Metin and D. İ. Çifçi, “Chemical Industry Wastewater Treatment by Coagulation Combined With Fenton and photo‐Fenton Processes,” Journal of Chemical Technology & Biotechnology, vol. 98, no. 5, pp. 1158–1165, 2023, doi: 10.1002/jctb.7321.

H. Q. Zhang, C. S. Ye, F. Yang, X. Zhang, H. Yang, and G. R. Liu, “Analysis of Organic Pollutants From Biologically Treated Coking Wastewater in a Multiple Barrier Method,” Adv Mat Res, vol. 641–642, pp. 165–168, 2013, doi: 10.4028/www.scientific.net/amr.641-642.165.

S. Veli et al., “Advanced Treatment of Pre-Treated Commercial Laundry Wastewater by Adsorption Process: Experimental Design and Cost Evaluation,” Journal of Ecological Engineering, vol. 20, no. 10, pp. 165–171, 2019, doi: 10.12911/22998993/113136.

E. Bazrafshan, M. R. Alipour, and A. H. Mahvi, “Textile wastewater treatment by application of combined chemical coagulation, electrocoagulation, and adsorption processes,” Desalination Water Treat, vol. 57, no. 20, pp. 9203–9215, 2016, doi: https://doi.org/10.1080/19443994.2015.1027960.

J. Yang, “Screening of Coagulant for Washing Wastewater Treatment,” Adv Mat Res, vol. 1092–1093, pp. 972–975, Mar. 2015, doi: 10.4028/www.scientific.net/AMR.1092-1093.972.

A. K. Verma, P. Bhunia, and R. R. Dash, “Applicability of a new pre-hydrated industrial grade polyaluminium salt for the decolourisation of textile wastewater,” Desalination Water Treat, vol. 52, no. 22, pp. 4553–4561, 2014, doi: https://doi.org/10.1080/19443994.2013.803776.

L. Zhou, S. Wang, Z. Li, X. Cao, R. Liu, and J. Yun, “Simultaneously removal of phosphorous and COD for purification of organophosphorus wastewater by catalytic ozonation over CaO,” Journal of Water Process Engineering, vol. 51, p. 103397, 2023, doi: https://doi.org/10.1016/j.jwpe.2022.103397.

T. Liu, X. Chen, X. Wang, S. Zheng, and L. Yang, “Highly effective wastewater phosphorus removal by phosphorus accumulating organism combined with magnetic sorbent MFC@La(OH)3,” Chemical Engineering Journal, vol. 335, pp. 443–449, 2018, doi: https://doi.org/10.1016/j.cej.2017.10.117.

Md. R. Awual, “Efficient phosphate removal from water for controlling eutrophication using novel composite adsorbent,” J Clean Prod, vol. 228, pp. 1311–1319, 2019, doi: https://doi.org/10.1016/j.jclepro.2019.04.325.

A. M. Adesoye, K. Olayinka, O. O. Olukomaiya, and P. O. Iwuchukwu, “The removal of phosphates from laundry wastewater using alum and ferrous sulphate as coagulants,” International Journal of Innovation and Scientific Research, vol. 8, no. 2, pp. 256–260, Sep. 2014, Accessed: Feb. 03, 2025. [Online]. Available: http://www.ijisr.issr-journals.org/abstract.php?article=IJISR-14-170-01

N. S. Ali and A. J. Jaeel, “Turbidity and TSS Removal From Textile Wastewater Using a Combination of Natural and Chemical Coagulants,” Wasit Journal of Engineering Sciences, vol. 7, no. 2, pp. 36–43, 2020, doi: 10.31185/ejuow.vol7.iss2.128.

Y. Zou, W. Zhang, and W. Zhou, “An Experimental Study on Choosing Coagulant and Determining Optimum Coagulation Conditions for Treating Wastewater From Regenerate Paper Industries,” in 2010 4th International Conference on Bioinformatics and Biomedical Engineering, IEEE, Jun. 2010, pp. 1–4. doi: 10.1109/icbbe.2010.5517479.

M. M. Momeni, D. Kahforoushan, F. Abbasi, and S. Ghanbarian, “Using Chitosan/Chpatc as Coagulant to Remove Color and Turbidity of Industrial Wastewater: Optimization Through RSM Design,” J Environ Manage, vol. 211, pp. 347–355, 2018, doi: 10.1016/j.jenvman.2018.01.031.

X. Zou et al., “Research on Hydraulic Loom Wastewater Using the Combined Process Containing Coagulation- Ozonation- Flotation Treatment,” in Proceedings of the 2016 International Conference on Civil, Structure and Environmental Engineering, Apr. 2016. doi: 10.2991/i3csee-16.2016.35.

DOI: http://dx.doi.org/10.12962/j25481479.v10i1.22559