Analysis of the Performance of Diesel Engine Fueled using B50-B100 Biodiesel Based on Simulation

Semin Semin, Beny Cahyono, Himmawan Aan Listyanto, Rosli Abu Bakar

Abstract


This alternative research fuels in the form of biodiesel from waste cooking oil. In addition, the purpose of this study is to determine the effect of waste cooking oil biodiesel blends in the performance testing of a one-cylinder diesel engine simulation modeling. The method used by the author in this study is to use a simulation method. Performance-based diesel motor performance tests are performed using HSD, and also with variations of used cooking oil biodiesel fuel mixtures. From the performance test results at full load, it was found that the comparison of the value of the power mix of biodiesel waste cooking oil with HSD decreased power. At B50 decreased power (6.38%), B60 (7.6%), B70 (8.9%), B80 (10.2%), B90 (11.4%), and B100 (12.7%) at maximum RPM. The torque value obtained in the biodiesel fuel mixture also decreased compared to HSD in the same cycle. The lowest SFOC value is produced by HSD fuel. SFOC HSD value is lower than cooking oil biodiesel mixture which is higher (6.8%) B50 fuel, up (8.3%) B60, up (9.83%) B70, up (11.4%) B80, up (12.9%) B90, and up (14.5%) B100 at full load and maximum RPM conditions.


Full Text:

PDF

References


Aziz, I. (2012). Uji Performance Mesin Diesel Menggunakan Biodiesel Dari Minyak Goreng Bekas. 2-3.

Gamma Technologies,(2004). GT-POWER User’s Manual 6.1, Gamma Technologies Inc.

Haryono, Fairus, S., Sari, Y., & Rakhmawati, I. (Januari, 2010). Pengolahan Minyak Goreng Kelapa Sawit Bekas menjadi Biodiesel Studi Kasus: Minyak Goreng Bekas dari KFC Dago Bandung. Pengembangan Teknologi Kimia untuk Pengolahan Sumber Daya Alam Indonesia.

Magfirotunnisa, Gunawan, & Saksono, P. (2018). ANALISIS PERBANDINGAN PENGGUNAAN BAHAN BAKAR SOLAR DENGAN BIODIESEL B15 DAN B20 TERHADAP PERFORMANSI. SNITT- Politeknik Negeri Balikpapan.

McCrady, J., Hansen, A., & Fon Lee, C. (2007). Modeling Biodiesel Combustion Using GT-Power. ASABE.

Misra, R., & Murthy, M. (2011). Blending of additives with biodiesels to improve the cold flow properties, combustion and emission performance in a compression ignition engine a review. Renew Sustain Energy, 15:2413–22.

Muwaffaq, A. H. (2016). Prediksi Performa Marine Diesel 4 Langkah 93 KW dengan Metode Simulasi.

Nirmala, N., Dawn, S., & Harindra, C. (2019). Analysis of performance and emission characteristics of Waste cooking oil and Chlorella variabilis MK039712.1 biodiesel blends in a single cylinder, four strokes diesel engine. www.elsevier.com/locate/renene.

Panji, R. (2019, Desember Senin). Rilis Bahan Bakar B30, Presiden Jokowi Perintah Kembangkan Hingga B100. Retrieved from Carmudi.co.id: https://www.carmudi.co.id/journal/rilis-bahan-bakar-b30-presiden-jokowi-perintah-kembangkan-hingga-b100

Raharjo, S. (2007). Analisa Performa Mesin Disel dengan Bahan Bakar Biodiesel dari Minyak Jarak Pagar. Prosiding Seminar Nasional Teknologi, B1-B6.

Semin, RA, B., & AR, I. (2007). Effect of Engine Performance For Four Stroke Diesel Engine Using SImulation. Proceeding The 5th International Conferences .

Semin, RA, B., & AR, I. (2008). Investigation of diesel engine performance based on simulation. American Journal of Applied Sciences, (6) 610-617.

Sheehan, J., Duffield, J., Garboski, M., & Shapouri, H. (1998). An overview of biodiesel and petroleum diesel life cycles. A report by US Department of Agriculture and Energy, 1–35.

Sugozu, I., Eryilmaz, T., Ors, I., & Solmaz, O. (2011). Biodiesel production from animal fat–palm oil blend and performance analysis of its effects on a single cylinder diesel engine. Energy Education Science and Technology Part A: Energy Science and Research.

Suwarsono, W. (2008). Sintesis Biodiesel dari Minyak Biji Ketapang Yang Tumbuh di Kapus UI Depok. Valensi, vol.1,no.2, 44-52.

Technologies Gamma Engine Perfomance Tutorial [Book],- Westmont : [s.n.],2016

www.wartaekonomi.com/indicator, 2006.

Yudisaputra, A. (2017). Analisis Pengaruh Angka Iodin Terhadap Proses Pembakaran Pada Motor Diesel.

Yuniarsi, K. (2007). Coco Metyl Ester (Cocodiesel) Sebagai Bahan Bakar Pengganti Solar. Jurnal Akta

Kimindo, vol 3, no.1, 17-20




DOI: http://dx.doi.org/10.12962/j25481479.v5i3.7520

Refbacks

  • There are currently no refbacks.


Abstracted / Indexed by:
      
  

 

 

 

 

 

P-ISSN: 2541-5972   

E-ISSN: 2548-1479

 

Lisensi Creative Commons

IJMEIR journal published by  Department of Marine Engineering, Faculty of Marine Technology, Institut Teknologi Sepuluh Nopember Surabaya Indonesia under licenced Creative Commons Attribution-ShareAlike 4.0 International Licence. Based on https://iptek.its.ac.id/index.php/ijmeir/