The Effect of Addition Electrical Supercharger on Diesel Dual Fuel Engine with Variation of Air Mass Flow Rate to The Engine Performance and Emissions

Jamaludin Jamaludin, Dori Yuvenda, Bambang Sudarmanta

Abstract


Diesel Dual fuel system is a diesel operated by using dual fuel CNG and diesel fuel as a pilot fuel. The problem that often occurs in dual fuel system is the reduced ratio of air and fuel. This causes the thermal efficiency to be lower. So in this study mounted electric supercharger as an air supply for performance and efficiency, and emissions from diesel engines better. This research uses diesel engine type Diamond Di 800 with dual fuel indirect injection model system. The method used is to vary the air mass flow rate (ṁ) through intake manifold to the combustion chamber 0.0063 kg/s, 0.0072 kg/s, 0.0077 kg/s, 0.0087 kg/s, and 0.0095 kg/s by adjusting the voltage on electric supercharger 8V, 9V, 10V, 11V, and 12V. Measurements are made to: the current and the voltage of each load, the consumption time of 25 ml diesel fuel, and the exhaust emissions (CO, HC, and PM). The best result was found that the addition of air mass flow rate (ṁ) to dual fuel system had no significant effect on the engine's effective power, torque, Bmep when compared with single fuel. The addition of air mass flow rate (ṁ) 0.0087 kg/s can substitution the diesel fuel by 56.45%, thermal efficiency increased by 33.57% but under single fuel condition, and increase the average AFR by 64.31%. The average CO and HC emissions decreased by 15.18% and 62.35% even though they were under single fuel condition, while the PM emissions increase with increasing loads but compared to single fuel decreased by 75%

Keywords


electric supercharger; diesel engine diamond type DI 800; engine performance; mass flow rate

Full Text:

PDF

References


F. Konigsson, “On Combustion in the CNG-Diesel Dual Fuel Engine,” Royal Institute of Technology, 2014.

J. B. Heywood, Internal Combustion Engine Fundamentals, Internat. ed. New York: McGraw-Hill, 1988.

D. Yuvenda and B. Sudarmanta, “Karakterisasi performa mesin sistem dual fuel menggunakan pressure reducer adaptive dengan variasi konstanta (k) pegas helix tekan dan tekanan gas keluar pada stage dua,” in Prosiding Seminar Nasional Manajemen Teknologi XXIII, 2015, p. 24.2-24.8.

A. Arif and B. Sudarmanta, “Karakterisasi performa mesin diesel dual fuel solar-CNG tipe LPIG dengan pengaturan start of injection dan durasi injeksi,” in Prosiding Seminar Nasional Manajemen Teknologi XXIII, 2015, p. 1.1-1.8.

Z. Wisnu and B. Sudarmanta, “Studi Eksperimen Pengaruh Variasi Start Of Injection Dan Durasi Pemasukan Bahan Bakar Compressed Natural Gas Terhadap Performa Mesin Diesel Sistem Dual Fuel,” Institut Teknologi Sepuluh Nopember, 2015.

R. G. Papagiannakis, C. D. Rakopoulos, D. T. Hountalas, and D. C. Rakopoulos, “Emission characteristics of high speed, dual fuel, compression ignition engine operating in a wide range of natural gas/diesel fuel proportions,” Fuel, vol. 89, no. 7, pp. 1397–1406, Jul. 2010.




DOI: http://dx.doi.org/10.12962/j23546026.y2019i1.5262

Refbacks

  • There are currently no refbacks.


View my Stat: Click Here

Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.