Nonlinear pH Control Based on Reaction Invariant and Self-Tuning PID Controller

Hendra Cordova, Heri Justiono, Ali Masduki

Abstract


pH neutralization process analytical model represents two processes dynamic. They mix reaction and reaction invariance that are achieved by solving the nonlinear electric charge balance acid-base. Reaction invariants are quantities that take the same values before, during and after a reaction. We identify a set of reaction invariants that are linear transformations of the species mole numbers. The material balances for chemically reacting mixtures correspond exactly to equating these reaction invariants before and after reaction has taken place. This research used HCl (strong acid) that is titrated by NaOH (Strong Base). All dynamic will perform nonlinear model, so we need the nonlinear controller scheme too. Therefore we choose the Self-Tuning- Controller (STCPID) that is part of adaptive control which has ability to handle nonlinearity and process load change. To find Figure of merit the STC in this work the control system compare with PID conventional controller scheme. The simulation result has a good and suitable performance under several tests (set-point and load change).

Keywords


Invariant Reaction; pH Neutralization; Adaptive Self-Tuning PID Controller (STCPID)

Full Text:

PDF

References


Fjeld., Asbjørnsen, O. A., Åström, K. J., 1974, Reaction Invariants and Their Importance in The Analysis of Eigenvectors, State Observability and Controllability of The Continuous Stirred Tank Reactor, Chem. Eng. Sci., 29.

Waller, K. V., Mäkilä, P. M., 1981, Chemical Reaction Invariants and Variants and Their Use in Reaction Modeling, Simulation, and control, Ind. Eng. Chem. Process Des. Dev., 20, 1- 11.

Gufftafson, T.K, and Waller, K.V., 1983, Dynamic Modeling and Reaction Invariant Control pH, Chemical Engineering Science, Vol.38, pp.389-398.

Cordova, H., 2003, Prototype Kontroler PID Self-Tuning Menggunakan Algoritma Auto-Switch Berbasis Margin Fasa dan Penguatan pada Proses Penetralan pH Larutan Campuran NaOH

dan HAC, [Laporan Akhir Penelitian DIKS ITS 2003] Lembaga Penelitian dan Pengabdian Pada Masyarakat –ITS.

Cordova, H., 2005, PID Control Systems Design to pH Neutralization by Neural Network Inverse Model Optimization at PT Petrokimia-Gresik, Prosiding Seminar FTI-ITS: Deindsutrialisasi Nasional: Ancaman Terhadap Pengembangan Daya Saing Global, hal. 20-22, Surabaya, Indonesia.

Cordova, H., 2005, The Application of Early Warning System for Monitoring and Control pH Water Based On Auto-Switch Algorithm, Prociding International Seminar and Disaster for Early Warning Systems PSB-ITS, 4-5 March, pp.10-13, Surabaya,

Indonesia.

Cordova, H., 2004, PID Self-Tuning Based on Auto-Switch Algorithm to Control pH Neutralization Process, Jurnal Industri, FTI-ITS, Vol. 3, hal.3-6.

Ishak., A,A., Hussain., M,A., 2001, Modeling and Control Studies of Waste Water Treatment Process., Proceeding to Brunei International Conference on Engineering & Technology, Bandar Seri Begawan, 9- 11 Oct, pp. 221-231.

Besharati, R, A., Lo, W, W., Tsang, K, M., 2001, Self-tuning PID Controller Using Newton-Raphson Method, IEEE Transaction On Industrial Electronic, Vol. 44, no.5, pp. 432-440.

Manzi, J.T.; Odloak, D., 1998, Control and Stability Analysis GMC Algorithm Applied to pH System, Braz. J. Chem. Eng. v. 15 n. 3 São Paulo Sept, pp.15-20, http:// www.scielo.br/scielo.php?Ing=es [2 September].

McAvoy, T., Hsu, E., Lowenthal, S., 1972, Dynamics of pH in Controlled Stirred Tank Reactor, Ind. & Eng. Chem., Process Descr. & Develop. 11(1), 67-70, 1972.

Loh, A, P., Looi, K, O., Fong, K, F., 2000, Neural Network Modeling and Control Strategies for a pH Process, Journal of Process and Control, Vol. 5 no. 6, pp. 3445-3450.

Cordova, H., 2006, Prototipe Kontroller Intelligent Self-Tuning PID pada Proses Penetralan pH dengan Metode Penalaan Newton-Rhapson, [Laporan Akhir Penelitian DIKS ITS 2006] Lembaga Penelitian dan Pengabdian Pada Masyarakat –ITS.

Cordova, H., Wijaya., AF., 2007, Self-Tuning PID Neural Network Controller to Nonlinear pH Neutralization on Waste Water Treatment, Jurnal IPTEK, ITS, vol. 18, n. 3, hal. 5-10.

Astrom, K.J., Wittenmark, B., 1995, “Adaptive Control”, Addison Wesley Publishing Company, USA., Page 150-250.

Bobál, V, Böhm, J, Fessl, J, Macháéca’k, J., 2005, Digital Self Tuning Controllers., Springer-Verlag., London., UK., Page. 130- 225.

Ylén, J-P., Measuring, 2001, Modeling and Controlling The pH Value and The Dynamic Chemical State., [Dissertation for the degree of Doctor], Department of Automation and Systems Technology., Helsinki University of Technology.

Boling., J,M., Seborg., D,E., Hespanha, J,P., 2006, Multi-Model Adaptive Control of a Simulated pH Neutralization Process, Elsevier Science., Vol. 3. no. 2. pp. 240-250.

Henson, M.A., Serborg, D.E., 1998, “Adaptive Nonlinear Control of a pH Neutralization Process,” IEEE Transaction on Control Systems Technology, vol. 2, no. 3 August.




DOI: http://dx.doi.org/10.12962/j20882033.v20i3.110

Refbacks

  • There are currently no refbacks.


Creative Commons License

IPTEK Journal of Science and Technology by Lembaga Penelitian dan Pengabdian kepada Masyarakat, ITS is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Based on a work at https://iptek.its.ac.id/index.php/jts.